Liang Buwei Joint Investigations To The Silicon Industry To Fight Excess Vaccina
with the National Development and Reform Commission Ministry of Industry and the National PV industry The joint investigation will directly contribute to the development of the two polysilicon industry requirements. Reporter learned yesterday, the Ministry of Industry will be as soon as possible “polysilicon industry access standards” (hereinafter referred to as “access standards”), and to study the development of “polysilicon industry guidance.”
Raise the access threshold, small businesses out
In September this year, State Council approved the National Development and Reform Commission reported “on the inhibition of overcapacity in some industries and duplication to guide the healthy development of industry, a number of opinions” that the new industries such as polysilicon, “there tend to repeat the construction.” According to the requirements of the State Council, Ministry of Industry, the State Development and Reform Commission recently, the country conducted a joint investigation photovoltaic industry.
It is understood that “access standards” will include enterprises to set up, layout, registered capital, Environmental protection Requirements, production scale, etc, refined recycling, energy consumption and other indicators, strengthen environmental protection requirements, determine the industry standard of product quality and prevention of occupational diseases, safety and production into account.
Requested the Ministry of Industry, the new polysilicon project size must be greater than 3000 tons / year, covers an area of less than 6 ha / tonnes of polysilicon, solar grade polysilicon to restore power consumption of less than 60 kWh / kg, reducing exhaust 4 silicon tetrachloride, hydrogen chloride, hydrogen recovery efficiency of not less than 98.5%, 99%, 99%; to guide and support the realization of polycrystalline silicon in a variety of businesses – power plants – Chemical industry Associates, support Energy Environmental technology development of solar grade polysilicon.
Expert: Industry “virtual surplus”
China Federation of Industry New Energy Deputy Secretary-General Shi Limin Chamber of Commerce, said yesterday, “the Ministry of Industry and in-depth research, to master the primary data, not only conducive to the polysilicon industry is not the right to amend the past, some development ideas, but also help enterprises to promptly adjust their development strategy.”
“I think the industry is now the ‘virtual surplus’, that does not exist in this industry a real surplus, but if not to manage and guide the future there may be excess.” Shi Limin analysis, the early development of polysilicon industry really hot, because it had about 400% of profits, many businesses and local governments, “surrounded them,” but so many projects at the initial stage of project, many project also points 1, 2, 3. Capacity is still not fully released, there was no surplus, at least to the end of this year does not appear.
PV leading enterprises: the actual output is poor
Shi Limin on the polysilicon production capacity to judge, in enterprises has been verified. Domestic photovoltaic leading enterprises Liu Zhibo, vice president of Suntech, told reporters that the current production capacity of polysilicon is “excess plan”, in fact, real output is poor.
“60% of current domestic polysilicon raw materials to be imported, the remaining 40% is not high-end products and high quality products.” Liu Zhibo introduced polysilicon industry status quo: not the total surplus of low quality, energy efficiency and low skill level. “Excess polysilicon is ‘table determined to’ excess capacity, and local governments to report material in excess of production capacity.”
The latest statistics show that domestic PV production this year will reach 3,500 MW, of which thin film solar cell production to 100 megawatts of silicon solar cell production was 3,400 megawatts. Calculated on this basis, this year, China still imported 14 thousand tons of polysilicon. “How could such a large gap in excess of it?” Liu Zhibo said.
MIIT: enterprises should take into account the international market
“Than an administrative order and regulate the industry through market rules determine polysilicon industry better.” Shi Limin that “now no longer blind corporate development, the industry has also bid farewell to the ‘windfall’ profits in a reasonable future to compete, companies will fine-tune their strategies according to the market. ”
I am a professional writer from Frbiz Site, which contains a great deal of information about frog figurines , battery operated lantern, welcome to visit!
Processing your request, Please wait....
