Agricultural machinery: the selection and use of edible fungi machinery – agricu
With the development of mushroom production, mushroom production services for the machine, have also been widely used. Here are some mushroom machine choice and use for reference. 1, wood cutting machine. Branches of wood, more forest thinning materials, should use MG? 600 or MG? 700 type, equipped with a 8.82 kilowatts or 13 kilowatts diesel motor, the diameter can be cut to 15? 18 cm of wood, the production rate of 1,500 per hour? 2000 kg . Use, first check the fly cutter and connecting bolts are tight. Working 4 hours per flying cutter needs sharpening once corrected with edge angle 36 ° Square. Section prevents stones, metal and other debris mixed; feeding hard, dry wood than when I add some to feed water to prevent the knife and heat softened volume edge. Feed port and the center of the direction of the entrance and exit of people can not stand to prevent the wood wounded. 2, wood grinder. The machine has FS? B, FS? C, FS? D versions. 100 000 bags of mushroom cultivation to processing chips 3000 kg per day may make use of a FS? D-type three-screen mill, equipped with 22 kilowatts or 22.05 kilowatts diesel motor. Production of about 300 kilograms per hour, mushroom, can use FS? B-type grinder. Use: (1) Open the cover tightened inspection hammer, the availability of loose bolts, and then add a little butter, start commissioning. (2) the machine is operating normally after the feed, if there abnormal sound, should immediately stop checks to avoid damage to the machine. (3) hammer wear lead to decreased productivity, should remove the exchange point of view of its use, or replaced with new hammer. (4) sets out the powder in the mouth of the bag, bending diameter of 300 mm, length greater than 5 meters, exhaust better. (5) feed must be uniform, do not overload. 3, training material bagging machine. The machine has A mushroom commonly used bagging machine and B-type mushroom, Tremella dual bagging machine, equipped with a 0.75 kilowatts motor, suitable for installation diameter of 120? 170 mm of blown film bags, the production rate of 800 per hour? 1000 bags. Use: (1) Check whether all parts of fastening screws, then connect the power supply when the machine was operating normally after the feeding. (2) bags, the primary light supporting the sleeve exit end of the primary lift up plastic bags, plastic bags, side to side slowly out of the feed. (3) use a different bag, need for appropriate mix agitated and bit-part player. (4) occasional overhead hopper, the material should be promptly flip bucket inside, not to put his hand in, to avoid rolling injuries. (5) If the machine is not expected to be down to check whether the auger wear or deformation. 4, autoclaves. The pot has a variety of specifications, can be installed 180? 250 bottles, fuel, coal, firewood available. Use: (1) pressure relief valve should be adjusted in about 147.12 kPa to automatically exhaust. (2) firing the pot add enough water before, bacteria bottle lying down in the pot to be stable, outside of the bacteria by bottle to keep the lid should be 110 mm distance. (3) The cover should be removed before the pot and the lid rubber ring corresponding Department of sludge impurities, to prevent leakage. (4) Sterilization cease-fire way not cool, cotton plugs to avoid cleaning the bathroom. (5) after sterilization, should play an open valve, the gas discharge pot, pressure pot to be 47.04? 98.08 kPa, close the release valve. The valve to open, drain the pot of water, then drain the pot of gas before opening the lid to take bottles. 5, dehydration dryer. The machine has XT? 40, XT? 60, XT? 80 other models, 18? 20 hours and dried mushrooms or fungus 35? 80 kg. Cultivation 50,000 bags of those shopping for a XT? 40 Dehydrated dryer can. Use a good temperature control; humidity and windows fully open in the early dry, mid-term half-open, full closed later. After drying the first fire, drying room and opened the access products. Continue to use the first heat exchanger pipes should be cleaned of soot.
I am Frbiz Site writer, reports some information about hinge knee brace , elastic ankle support.
Processing your request, Please wait....
